Golf cart electric motor test

Engine from Golf cart with the bed is going through its electrical test. Cushman Golfster 36V DC motor test. I plugged in the charger and put the back on jackstands and hit the gas and it spun.

You will be testing for continuity, which basically means you are testing for an electric connection between two points. Note that continuity is non-directional.

Below are just some simple test that may indicate a.

The first two trys were wired wrong, and only sparked.

One terminal goes to A then Aconn. How to diagnose If your volt cart is performing properly. There are many different systems to consider when troubleshooting your electric golf cart motor.

Looking for advice on how to fix my golf cart.

Turns out the the Reed switch was bad. Got everything back together and charged up the batteries. It accelerates better, climbs hills better and runs faster flat out. How To Check The Rear Axle Fluid . HP cont Wiring: Sto Ato controller ASto controller M-.

HD solenoid installalso new batteries.

Be certain that the battery pack . Test video for 12v-48v dc motor speed controller 25A or 50A - Duration: 8:25. V DC motor test - Duration: 4:28. Electric motor volt test - Duration: 0:41.

Here is some of the first tests of my newly designed and prototyped 500A controller.

This is the first power-up bench test of the AC-electric motor and Curtis controller that will go in my electric bike conversion. The motor on the Dyno machine is for golf carts. I can help you with your project.

Check the cable connections, the forward and reverse switch, and the motor.

MOTOR UNWANTED CONTINUITY TEST The following tests can assist in troubleshooting. Disconnect all wires to the motor and label them. Make sure none of the terminals are grounded to the motor or cart (Fterminal to motor frame) You . Vehicles that incorporate the PowerDrive System include: 1) DS electric golf car, 2) Fairway Villager electric , 3) Tourall electric , 4) Carryall I, II, .